Registration Dossier
Registration Dossier
Data platform availability banner - registered substances factsheets
Please be aware that this old REACH registration data factsheet is no longer maintained; it remains frozen as of 19th May 2023.
The new ECHA CHEM database has been released by ECHA, and it now contains all REACH registration data. There are more details on the transition of ECHA's published data to ECHA CHEM here.
Diss Factsheets
Use of this information is subject to copyright laws and may require the permission of the owner of the information, as described in the ECHA Legal Notice.
EC number: 226-106-9 | CAS number: 5280-78-4
- Life Cycle description
- Uses advised against
- Endpoint summary
- Appearance / physical state / colour
- Melting point / freezing point
- Boiling point
- Density
- Particle size distribution (Granulometry)
- Vapour pressure
- Partition coefficient
- Water solubility
- Solubility in organic solvents / fat solubility
- Surface tension
- Flash point
- Auto flammability
- Flammability
- Explosiveness
- Oxidising properties
- Oxidation reduction potential
- Stability in organic solvents and identity of relevant degradation products
- Storage stability and reactivity towards container material
- Stability: thermal, sunlight, metals
- pH
- Dissociation constant
- Viscosity
- Additional physico-chemical information
- Additional physico-chemical properties of nanomaterials
- Nanomaterial agglomeration / aggregation
- Nanomaterial crystalline phase
- Nanomaterial crystallite and grain size
- Nanomaterial aspect ratio / shape
- Nanomaterial specific surface area
- Nanomaterial Zeta potential
- Nanomaterial surface chemistry
- Nanomaterial dustiness
- Nanomaterial porosity
- Nanomaterial pour density
- Nanomaterial photocatalytic activity
- Nanomaterial radical formation potential
- Nanomaterial catalytic activity
- Endpoint summary
- Stability
- Biodegradation
- Bioaccumulation
- Transport and distribution
- Environmental data
- Additional information on environmental fate and behaviour
- Ecotoxicological Summary
- Aquatic toxicity
- Endpoint summary
- Short-term toxicity to fish
- Long-term toxicity to fish
- Short-term toxicity to aquatic invertebrates
- Long-term toxicity to aquatic invertebrates
- Toxicity to aquatic algae and cyanobacteria
- Toxicity to aquatic plants other than algae
- Toxicity to microorganisms
- Endocrine disrupter testing in aquatic vertebrates – in vivo
- Toxicity to other aquatic organisms
- Sediment toxicity
- Terrestrial toxicity
- Biological effects monitoring
- Biotransformation and kinetics
- Additional ecotoxological information
- Toxicological Summary
- Toxicokinetics, metabolism and distribution
- Acute Toxicity
- Irritation / corrosion
- Sensitisation
- Repeated dose toxicity
- Genetic toxicity
- Carcinogenicity
- Toxicity to reproduction
- Specific investigations
- Exposure related observations in humans
- Toxic effects on livestock and pets
- Additional toxicological data
Endpoint summary
Administrative data
Description of key information
Disazocondensation red pigments were found to non toxic upon acute oral toxicity testing in rat with doses being tested in the range of 2000 and 10000 mg/kg bw. They are non toxic upon acute skin contact based on experimental data with Pigment Red 144 obtained with rabbits and based on the physico-chemical properties which indicate absent or very low skin permeability.
Key value for chemical safety assessment
Acute toxicity: via oral route
Link to relevant study records
- Endpoint:
- acute toxicity: oral
- Type of information:
- experimental study
- Adequacy of study:
- key study
- Reliability:
- 2 (reliable with restrictions)
- Rationale for reliability incl. deficiencies:
- comparable to guideline study with acceptable restrictions
- Qualifier:
- equivalent or similar to guideline
- Guideline:
- OECD Guideline 401 (Acute Oral Toxicity)
- Deviations:
- yes
- Remarks:
- 30 mL test preparation per kg bw; 8 days observation period, individual test results missing, no data on necropsy
- GLP compliance:
- no
- Test type:
- standard acute method
- Limit test:
- no
- Species:
- rat
- Strain:
- other: CFE (RAC; SPF)
- Sex:
- male/female
- Details on test animals or test system and environmental conditions:
- TEST ANIMALS
- Source: breeder; random breed
- Age at study initiation: young
- Weight at study initiation: 107-147 g
- Housing: in groups of 5 in macrolon cages (size 3)
- Diet (e.g. ad libitum): Nafag, ad lib.
- Water (e.g. ad libitum): drinking water, ad lib.
- Acclimation period: at least 5 days
ENVIRONMENTAL CONDITIONS
- Temperature (°C): 22+-1
- Humidity (%): 55+-5
- Photoperiod (hrs dark / hrs light): 10/14 - Route of administration:
- oral: gavage
- Vehicle:
- CMC (carboxymethyl cellulose)
- Remarks:
- aqueous suspension with 0.5% CMC
- Details on oral exposure:
- VEHICLE
- Concentration in vehicle: 25/ 33.3%
MAXIMUM DOSE VOLUME APPLIED: 30 mL/kg bw - Doses:
- 5000 and 10000 mg/kg bw
- No. of animals per sex per dose:
- 5
- Control animals:
- no
- Details on study design:
- - Duration of observation period following administration: 8 days
- Frequency of observations and weighing: observations: no data; weighing at day 0 and day 8
- Necropsy of survivors performed: not reported - Sex:
- male/female
- Dose descriptor:
- LD50
- Effect level:
- > 10 000 mg/kg bw
- Based on:
- test mat.
- Remarks on result:
- other: only unspecific clinical signs observed
- Mortality:
- not observed
- Clinical signs:
- other: 5000 mg/kg bw: piloerection 10000 mg/kg bw: ataxia, sedation, piloerection, inhibition of spontaneous motility, red stained urine and feces
- Interpretation of results:
- GHS criteria not met
Reference
Endpoint conclusion
- Endpoint conclusion:
- no adverse effect observed
- Dose descriptor:
- discriminating dose
- Value:
- 5 000 mg/kg bw
- Quality of whole database:
- Reliable and valid.
Acute toxicity: via inhalation route
Endpoint conclusion
- Endpoint conclusion:
- no study available
Acute toxicity: via dermal route
Link to relevant study records
- Endpoint:
- acute toxicity: dermal
- Type of information:
- experimental study
- Adequacy of study:
- key study
- Reliability:
- 2 (reliable with restrictions)
- Rationale for reliability incl. deficiencies:
- other: Comparable to guideline study with acceptable restrictions (TS purity not specified; size of application area not reported; 4 animals used (without justification); abraded skin was treated in 2 animals)
- Qualifier:
- equivalent or similar to guideline
- Guideline:
- OECD Guideline 402 (Acute Dermal Toxicity)
- Deviations:
- yes
- Remarks:
- 4 animals used (without justification); abraded skin was treated in 2 animals; size of application area not reported
- GLP compliance:
- no
- Test type:
- standard acute method
- Limit test:
- yes
- Species:
- rabbit
- Strain:
- New Zealand White
- Sex:
- male/female
- Details on test animals or test system and environmental conditions:
- TEST ANIMALS
- Source: local supplier
- Age at study initiation: 8-11 weeks
- Weight at study initiation: 2.5-2.7 kg
- Housing: individually in elevated wire mesh cages
- Diet (e.g. ad libitum): Purina Rabbit Chow ad lib.
- Water (e.g. ad libitum): water from bottles ad lib.
- Acclimation period: at least 7 days
ENVIRONMENTAL CONDITIONS
Housing in temperature controlled rooms (no further details) - Type of coverage:
- occlusive
- Vehicle:
- water
- Details on dermal exposure:
- TEST SITE
- Area of exposure: back, intact or abraded skin (each 2 animals; abraded with a 21 gauge bent tip needle. The abrasions, made every 2 to 3 cm longitudinally, scratched the stratum corneum, but did not disturb the derma or produce bleeding)
- % coverage: not reported (regarding the body weight of ca. 2500 mg and the formula BSA = 9.5 * (body weight in g)exp(2/3), the test site should be > 180 cm2 for guideline conformity)
- Type of wrap if used: impervious material
REMOVAL OF TEST SUBSTANCE
- Washing (if done): warm tap water
TEST MATERIAL
- Concentration (if solution): 50% w/v suspension in distilled water
- Constant volume or concentration used: yes - Duration of exposure:
- 24 h
- Doses:
- 2000 mg/kg bw
- No. of animals per sex per dose:
- 2
- Control animals:
- no
- Details on study design:
- - Duration of observation period following administration: 14 days
- Frequency of observations and weighing: observations: once daily; weighing once weekly
- Necropsy of survivors performed: yes
- Other examinations performed: evaluation of local effects according to OECD Draize scheme after 25 hours, 7 and 14 days - Sex:
- male/female
- Dose descriptor:
- LD50
- Effect level:
- > 2 000 mg/kg bw
- Based on:
- test mat.
- Remarks on result:
- other: Abrasion (2/4 animals) had no effect on local or systemic effects
- Mortality:
- no mortality
- Clinical signs:
- other: in 1 animal (intact skin): Diarrhea, days 3 & 4 and 7 to 10; Abdomen bloated, days 4 to 7; Anorexia, days 5 and 6; Adipsia, days 5 and 6; no fecal matter in pan day 5.
- Gross pathology:
- One animal had yellow exudate from nose/mouth and another had bloated intestines. No abnormal findings in the other two animals (with abraded skin).
- Other findings:
- Neither erythema nor edema were observed.
- Interpretation of results:
- GHS criteria not met
Reference
Endpoint conclusion
- Endpoint conclusion:
- no adverse effect observed
- Dose descriptor:
- discriminating dose
- Value:
- 2 000 mg/kg bw
Additional information
Acute oral toxicity was studied with Pigment Red 144 in rats in three studies performed between 1965 and 1978. The studies were performed prior to the introduction of GLP, but two of them are reported in adequate detail for evaluation. The procedures are comparable to OECD gtesting guideline 401. In the key study, doses of 5000 and 10000 mg/kg bw were applied to each 5 male and female rats. During the observation period of 8 days, the dose of 5000 mg/kg bw caused piloerection whereas at 10000 mg/kg bw: ataxia, sedation, piloerection, inhibition of spontaneous motility, red stained urine and feces were observed. No mortality was observed. In the supporting study, a single dose of 5000 mg/kg bw was applied to male and female rats by gavage and the observation period was 14days. Also in that study, no mortality was observed.
Acute dermal toxicity was studied with Pigment Red 144 in rabbits (MBRL1978). The study was performed prior to the introduction of GLP, but is reported in adequate detail for evaluation. In deviation to the current OECD testing guideline, only 4 animals (2 male and 2 female) were used and abraded skin was treated in 2 animals. The size of application area is not reported. These differences are minor, and considering survival of all four animals the outcome of the study would not have been different in a fully OECD 402 guideline compliant study. The dose of 2000 mg/kg bw was applied using water for moistioning with occlusive wrapping for 24h. No local effects were observed. One animal with intact skin showed transient clinical signs.
Regarding acute inhalation toxicity, a study with whole-body exposure to Pigment Red 220 was performed at the CRO which was later sued for having falsified study reports (IBT 1972). This report itself appears to be plausible, since the findings regarding the focal red discoloration and the particle sizes make sense.The test concentration in testing atmosphere was 2.2 mg/l. Details on analytical verification of test atmosphere concentration are not provided.The method of particle size determination is described as follows: A sample of airborne dust was collected from the test atmosphere for the purpose of conducting a microscopic determination of particle size distribution. Particles were counted with respect to three size ranges, viz. 5 µm or smaller (considered to be respirable), 6-25 µm and >25 µm. The smallest particle which could be detected by the light-field technique employed was approximately one µm. The largest particle observed was also recorded. 55% of the particles were in the range of less than 5 µm and 35% were in the range of 6-25 µm. No deaths were noted during the four-hour exposure period or 14-day observation period which followed. Necropsy, performed on all animals at the end of the two-week observation period, revealed slight to moderate diffuse focal red discoloration of the lungs in six rats. There were no other gross pathologic alterations in any of the other tissues and organs examined.
The reported procedure and findings are plausible and would be expected for red inert pigments that are too large for passive permeation through biological membranes.
The pigments are not have irritating or sensitizing properties and are expected to cause effects via excessive deposition at high doses. Based on experience with inert organic pigments, these do not result in mortality in acute inhalation exposure studies. Exposure to inhalable dust must be controlled, and at acceptable levels (3 mg/m3) no substance-specific acute inhalation hazard is expected. Further testing of acute inhalation testing was therefore not performed.
Table: Overview on the experimental acute toxicity data for disazocondensation red pigments and the respective amines
|
PR 262 |
PR 166 |
PR 144 |
PBr 41 |
PBr 23 |
PR 214 |
PR 220 |
PR 221 |
PR 242 |
79665-24-0 |
3905-19-9 |
5280-78-4 |
68516-75-6 |
35869-64-8 |
40618-31-3 |
68259-05-2 |
71566-54-6 |
52238-92-3 |
|
Mol. weight |
781.7 |
794.5 |
828.9 |
844.5 |
850.0 |
863.4 |
925.8 |
925.8 |
930.5 |
Water solubility (μg /L) |
16.4 |
<6.5 |
11.2 |
0.5 – 1 |
<20 |
6.1 |
14.2 |
91 |
18.9 |
n-octanol solubility (μg /L) |
55.4 |
<6.5 |
21.9 |
56 |
<20 |
17.8 |
<10 |
24 |
41 |
Log Pow (calculated from solubilities) |
0.53 |
n.a. |
0.29 |
1.7 - 2.1 |
n.a. |
0.47 |
<-0.15 |
-0.57 |
0.33 |
acute oral tox (LD50 in mg/kg bw, rat) |
> 5000 K1 |
> 5000 K2 |
> 10 000 K2 |
>5000 K4 |
> 10 000 K2 |
> 5000 K1 |
> 5000 K1 |
> 5000 K1 |
> 2000 K1 |
acute dermal tox (LD50 in mg/kg bw, rat) |
|
|
> 5000 K2 |
>5000 K4 |
|
|
|
>3000 K4 |
|
acute inhalation tox (LC50 in mg/m3, rat) |
|
|
|
|
|
|
> 2200 K2 |
|
|
CAS of amine A |
95-79-4 |
95-82-9 |
95-82-9 |
608-27-5 |
89-63-4 |
95-82-9 |
none |
none |
121-50-6 |
acute oral tox (LD50 in mg/kg bw, rat) amine A |
700* |
1600* |
1600* |
940*, 2500* |
|
1600* |
|
|
|
CAS amine B |
6393-01-7 |
106-50-3 |
615-66-7 |
2243-62-1 |
615-66-7 |
20103-09-7 |
6393-01-7 |
20103-09-7 |
20103-09-7 |
acute oral tox (LD50 in mg/kg bw, rat) amine B |
27** |
ca 300* |
ca 1500 (mice)** |
>2000* |
ca 1500 (mice)** |
>5000** |
27** |
>5000** |
>5000** |
Pigment Red 262 (CAS 79665-24-0, 782 g/mol)
Pigment Red 262 was evaluated in a GLP and OECD 423 compliant study in rats with the limit dose of 5000 mg/kg bw (RCC 1988). Clinical signs involved sedation, dyspnea (males), hunched posture, ruffled fur. All rats recovered within six observation days. No mortality occurred.
Pigment Red 166 (CAS 3905-19-9, 794.5 g/mol)
Pigment Red 166 was tested in valid studies in rats (Ciba-Geigy Ltd 1975), mice (Ciba-Geigy Ltd 1980) and hamsters (Ciba-Geigy Ltd 1980) that were performed prior to the introduction in GLP, but according to procedures similar to OECD guidelines for acute oral toxicity.
The study in rats was performed at doses of 1000, 3000, 10000 and 15000 mg/kg bw in each five male and female rats with a 14-day observation period. Clinical symptoms at lowest dose (1000 mg/kg) was hyperreflexia which resolved within 24h. At the other dose levels (3000, 10000, 15000 mg/kg) additionally transient reduction in spontanous motility, ataxia and irregular respiration occurred. No mortality occurred.
The study in mice was performed at doses of 3000, 4000, 5000 mg/kg bw in each 5 male and female animals with a 14-day observation period. Each one animal in the mid and in the high dose died.Following effects were seen in the first week of observation: sedation - all doses until 5hrs after application, highest dose until 3rd day after application (slight effects); dyspnoea: all doses until 7th day after application (slight effects); ruffled fur: all doses until 6th day after application (slight and moderate effects); diarrhoe: all doses 24 hrs after application until 4th day (slight effects); curved body position: all doses until 5th day after application. No effects seen in the 2nd week of observation. Gross necropsy did not reveal adverse findings.
The study in Chinese hamster was performed at doses of 3000, 4000 and 5000 mg/kg bw in each five male and female animals with a 14-day observation period. Clinical symptoms (sedation, dyspnoea, exophthalmos, ruffled fur, curved body position) were observed from day 1 to 6. No mortality occurred.
Pigment Red 144 (CAS 5280-78-4, 829 g/mol)
Pigment Red 144 was tested in valid studies in rats (Ciba-Geigy Ltd 1972, MBRL1975, Ciba AG 1965) that were performed prior to the introduction in GLP, but according to procedures similar to OECD guidelines for acute oral toxicity.
The first study was performed similar to OECD guideline 401,with the deviations that 30 mL test preparation per kg bw were applied, that the observation period was only 8 days, that individual test results are missing and that no data on necropsy is provided. Each five male and female rats received a single dose of 5000 or 10000 mg/kg bw. The vehicle was an aqueous suspension with 0.5% carboxymethyl cellulose. At 5000 mg/kg bw piloerection was observed, at 10000 mg/kg bw ataxia, sedation, piloerection, inhibition of spontaneous motility, red stained urine and feces were observed.
The second study was performed following the procedure of OECD guideline 401 in each five male and female rats at a single dose of 5000 mg/kg bw. Red diarrhea was observed after 4 hours in 4 animals; chromorhinorrhea after 2 days in 1 animal; ptosis after 12 and 13 days in one animal and chromodacryorrhea after 13 and 14 days in the same animal. Gross necropsy showed purple lung areas in two animals, mottled liver in one animal and mottled kidneys in another animal. Findings in lung indicate a gavage error, although this is not specifically mentioned in the report.
Pigment Brown 41 (CAS 68516-75-6, 844 g/mol)
Poorly documented experimental data is available (Sandoz 1975). It reports that the LD50 for acute oral and dermal toxicity in rat is greater than 5000 mg/kg bw without further details on method, species or sex. The order and the reporting dates lie 2 month apart.
Pigment Brown 23 (CAS 35869-64-8, 850 g/mol)
Pigment Brown 23 was tested in a valid study in rats (Ciba-Geigy Ltd 1973) that was performed prior to the introduction in GLP, but according to procedures similar to OECD guidelines for acute oral toxicity. The design included only a 7-day observation period and body weights determined only at study start. Each five male and female rats received a single dose of 6000 or 10000 mg/kg bw. Within 2 hours after treatment the rats of both dosage groups showed dyspnoea, exophthalmus, curved position and ruffled fur. These symptoms became more accentuated as the dose was increased. The animals had recovered within 3 to 6 days. No mortality occurred. No substance related gross organ changes were seen at necropsy.
Pigment Red 214 (CAS 40618-31-3, 863 g/mol)
Pigment Red 214 was tested in two valid studies in rats (RCC 1989 and 2006). Both studies are GLP and OECD 423 compliant. No animal died at the limit dose of 2000 mg/kg bw. In the more recent study, all animals expressed a slightly ruffled fur throughout the day of dosing. In addition, a hunched posture was noted in three animals at the 3-hour reading. Red staining of the feces was noted for all animals on days 2 and 3 and for the first dosing group already at the 5-hour reading.No macroscopic findings were recorded at necropsy. In the other study, all rats had recovered within three observation days from sedation and unsteady gait and ruffled fur. The results are consistent with poorly documented information indicating an LD50 of greater than 15000 mg/kg bw (Andrysova 1978).
Pigment Red 220 (CAS 68259-05-2, 926 g/mol)
Pigment Red 220 was studied for acute oral toxicity in four studies of which only one is reliable and adequate (Ciba-Geigy Ltd 1987). The study was performed according to GLP and OECD guideline 401 with a limit dose of 5000 mg/kg bw. No mortality occurred. Dyspnea, exophthalmos, ruffled fur, and curved body position were seen, being common symptoms in acute tests. Additionally, a red discoloration of the body was observed from day 1 to 4 after administration. The animals recovered within 11 days. The information is consistent with poorly documented data from 1965 and a study run at CRO that was known to have falsified study reports (IBT 1972).
Pigment Red 221 (CAS 71566-54-6, 926 g/mol)
Pigment Red 221 was studied for acute oral toxicity in three studies of which two are reliable and adequate (Ciba-Geigy 1974, Centre de Recherches Biologiques 1983).
The study performed in 1974 has the deficiencies of an observation period of only 7 days. Tested doses were 2150, 3170 and 4640 mg/kg bw/day. Within 2 hours after treatment the rats in all dosage groups showed dyspnoea, exophthalmus, curved position, and ruffled fur. All animals had recovered within 4 to 7 days. No mortality occurred.
The study performed in 1983 had the deficiency that no necropsy was performed at the end of the study. All animals survived the single dose of 5000 mg/kg bw.Immediately following application, piloerection and apathy were observed; these symptoms however disappeared rapidly during the course of the observation period.
Pigment Red 242 (CAS 52238-92-3, 931 g/mol)
A GLP and OECD 401 compliant study was performed with rats (Sandoz 1991). A single dose of 2000 mg/kg was tolerated by all rats without showing clinical signs or any other adverse effect.
Justification for classification or non-classification
Dangerous Substance Directive (67/548/EEC)
The available studies are considered reliable and suitable for classification purposes under 67/548/EEC. As a result the substance is not considered to be classified for acute oral or dermal toxicity under Directive 67/548/EEC, as amended for the 31st time in Directive 2009/2/EG.
Classification, Labelling, and Packaging Regulation (EC) No. 1272/2008
The available experimental test data are reliable and suitable for classification purposes under Regulation 1272/2008. As a result the substance is not considered to be classified for acute oral or dermal toxicity under Regulation (EC) No. 1272/2008, as amended for the third time in Directive EC 618/2012.
Information on Registered Substances comes from registration dossiers which have been assigned a registration number. The assignment of a registration number does however not guarantee that the information in the dossier is correct or that the dossier is compliant with Regulation (EC) No 1907/2006 (the REACH Regulation). This information has not been reviewed or verified by the Agency or any other authority. The content is subject to change without prior notice.
Reproduction or further distribution of this information may be subject to copyright protection. Use of the information without obtaining the permission from the owner(s) of the respective information might violate the rights of the owner.